The stator is
the coil of wire housed inside the engine case
. A magnet on a shaft spins within the stator, creating alternating current (AC). That current travels along fairly heavy gauge wire through the case and into the rectifier/regulator which converts it to DC power, and at a consistent output.
How do I know if my stator is bad?
The most obvious symptoms of a bad motorcycle stator include no spark, weak spark, or intermittent spark (also known as misfiring).
Hard starts
and a poorly running engine can also be clues that your stator needs to be rebuilt or replaced.
What happens when a stator goes bad?
The most obvious symptoms of a bad motorcycle stator include no spark, weak spark, or intermittent spark (also known as misfiring). Hard starts and a poorly running engine can also be
clues that your stator needs to be rebuilt or replaced
. In this article we will dig into these symptoms and what causes them.
Does a stator charge the battery?
Your stator is a pretty
vital piece
of the electrical system on your bike. In simple terms, if you’re riding a modern bike, it has many electrical needs. … Think of your stator as the piece that makes electricity to keep your battery charged up to make all that electrical stuff on your bike work.
What causes stator to go bad?
To answer why stators fail, it is because
the coating on the windings breaks down, usually because of heat
, causing a short which can also burn the fine wire of the winding in two at the short causing an open circuit. The way to prevent failures is to prevent the heat.
Can a bad stator damage a battery?
As far as the battery,
yes a bad stator/regulator can destroy a new battery
. If it’s run at a very low voltage without being recharged then it can be destroyed. It actually happens all the time. In most cases if we replace a stator or regulator the battery has to be changed as well as it won’t hold a charge.
Can a bad stator drain a battery?
The role of the stator is to charge the battery while the motorcycle is on. When a stator has gone bad, that means
the motorcycle is running off of battery power alone which will quickly drain it
. Batteries were not made to power the bike while it’s running, only mainly to get it started.
Can a stator be repaired?
Stator Replacement
In many cases a new stator is the safest, most cost-effective solution for an electrical system breakdown. Because
repairing stators can be an intricate and detail-intensive process
, replacing failed stators with an entirely new part can be a much easier route, depending on the specific motorcycle.
Can you clean a stator?
If you want to clean oil you can use
carburator cleaner
or similar product like choke cleaner, it would take the oil out and any residual will evaporate or any contact cleaner will work too. Thats on the stator and the aluminum will clean both.
Will a quad start with a bad stator?
The stator of an ATV works to recharge your battery while your vehicle is running, similar in function to a car’s alternator. When the stator goes bad,
your ATV will only run until the battery goes dead
, which is not very long.
How hard is it to replace a stator?
Replacing the stator is not too complicated and requires
a socket set and some heat resistant gasket repair silicone only
. … On 2006-07 Honda Fireblades the stator is located on the left hand side behind the crash protector.
How do I know if my stator or rectifier is bad?
Key Signs to Look For
You won’t have any trouble diagnosing the faulty regulator rectifier if the battery is the cause. You’ll note signs right away like poor starts,
fluctuating meter readings, and dimmed headlights
. around 13 volts, the bike will start to drain the battery.
How long do you have to ride a motorcycle to charge the battery?
The time it takes to charge a motorcycle battery is
about 4 to 24 hours
. Each battery and charger can influence the time it takes to charge your battery.
Can a stator go bad from sitting?
Stators do not go bad from sitting unless the mag housing is full of water
.
Can you overload a stator?
It becomes a 40w or 90w heater and will likely burn out in time. An overload on the
stator will not burn it out
, it simply will not reach 12v so lights will be dim.
