Tour riding a stock bike your clutch should last
over 100,000 miles
. Doing burn-outs with a 110′′ engine will shorten that life quite a bit. Keep it adjusted and keep good, clean fluid in your primary. Your cable probably won’t last as long but if you keep it lubricated as well you’ll extend it’s life quite a bit.
How long should a motorcycle clutch cable last?
Typically you can expect your a motorcycle clutch to last
between 20 000 and 60 000 miles
. A clutch that is often slipped in the friction zone and that is not properly maintained may need replacement after as little as 5 000 miles, while many riders do well over 100 000 miles on the original clutch.
When should I replace motorcycle clutch cable?
If you see any frays or wear indications in the cable threads
, it’s time to replace it. Lube it every oil change and if’n you’re smart, carry a Save URide cable…just in case.
How do I know if my clutch cable is bad?
- Transmission slips out of gear. A bad clutch cable can sometimes cause a transmission to slip and pop out of gear. …
- Hard clutch pedal. Another symptom of a problem with the clutch cable is a hard clutch pedal. …
- Clutch pedal sinks to the floor.
How do I know if my Harley clutch is bad?
To tell if your motorcycle clutch is bad, you’ll need to look for signs such as
unexplained high revs and lowered gas mileage
. Other signs of a bad clutch may also include a stuck clutch lever, hard shifts accompanied by a clunking sound or jerk, and difficulty getting the motorcycle to shift gears.
What happens if your clutch cable breaks on motorcycle?
A broken clutch cable or a broken lever will sure give you some headaches. Fortunately, the motorcycle gearbox can handle a lot of badass gearshifts. You don’t have to worry. It’s not difficult, and all you only have to do is to focus on
the throttle
.
How much does it cost to replace a clutch cable on a motorcycle?
Clutch Cable Replacement Cost – RepairPal Estimate. Labor costs are estimated
between $85 and $107
while parts are priced between $83 and $115.
How do I know when my clutch needs replacing?
- Spongy, sticking, vibrating or loose clutch pedal when pressed.
- Squeaking or grumbling noise when pressed.
- Ability to rev the engine, but poor acceleration.
- Difficulty shifting gear.
Can a clutch fail suddenly?
Clutches tend to fail in one of two ways – either
suddenly
or gradually. … Sudden failure is most often caused by a broken or loose clutch cable, linkable or a failed hydraulic master/slave cylinder. There can also be leaks in the hydraulic line or even the disc could be contaminated with something like dirt or debris.
What causes clutch cable break?
What can cause a snapped clutch cable?
Bad clutch pressure plate
– The clutch pressure plate applies pressure to the clutch, holding it against the flywheel. Sometimes, a bad or damaged pressure plate can put high levels of stress onto the clutch cable, leading to it snapping and breaking.
Can you fix a slipping clutch without replacing it?
A slipping clutch could result in damage to the pressure plate and flywheel, if not properly fixed. If you do not have experience in replacing clutches — it’s best to find a professional who
has been trained and certified in slipping clutch repair
.
Is it OK to slip a motorcycle clutch?
When you slip it, you only let them make partial contact, so the engine might be spinning at 9000rpm, but the bike is only putting part of that power into forward movement, because
the clutch is not fully engaged
.
What does clutch slipping feel like motorcycle?
Symptoms: A slipping clutch is quickly recognizable when you’re
twisting the throttle with reckless abandon while the machine is
in gear, yet the rear wheel isn’t rotating in unison with the engine’s rpm. If you’re wound out in third gear and only accelerating at a snail’s pace, then something is wrong.
How much does it cost to fix a clutch cable?
Clutch Cable Replacement Cost – RepairPal Estimate.
Labor costs are estimated between $85 and $107
while parts are priced between $83 and $115. This range does not include taxes and fees, and does not factor in your specific vehicle or unique location.
Are clutch cables interchangeable?
Yes you can…
all the clutch cables have the same ends
… they only vary in length… and you can get good used ones on ebay through Pinwall MC Salvage…. cheap….
How do you replace a clutch cable?
Clutch Cable Replacement Cost – RepairPal Estimate. Labor costs are
estimated between $85 and $107
while parts are priced between $83 and $115. This range does not include taxes and fees, and does not factor in your specific vehicle or unique location.
