5,000 service ’14 Ultra Limited, $397 with synthetics. ’05 Heritage Classic stator replacement,
$115
.
How much does it cost to get a stator replaced?
A new stator and rotor set typically costs
between $250 and $1,500
. They are stationary and rotating parts of any system that generates electricity. When they stop working seamlessly, they need repair or replacement.
How long does it take to replace a stator on a Harley?
How long does it take to replace a stator? You should be able to get in and out
under 3 hours
.
How long does it take to replace a stator?
A good tech can change a stator
in 3 hours
and a belt in 6 or 7 hours. Your belt should go over 100,000 if it has been properly maintained.
What are the symptoms of a bad stator on a Harley Davidson?
The most obvious symptoms of a bad motorcycle stator include
no spark, weak spark, or intermittent spark
(also known as misfiring). Hard starts and a poorly running engine can also be clues that your stator needs to be rebuilt or replaced.
How hard is it to replace a stator?
Replacing the stator is not too complicated and requires
a socket set and some heat resistant gasket repair silicone only
. … On 2006-07 Honda Fireblades the stator is located on the left hand side behind the crash protector.
What would cause a stator to go bad?
There are a few things that may cause a stator to fail.
Too heavy of a load when operating accessories (winch,heated grips,headlights, etc)
. If working several of these items at one time (plowing/pulling/possibly stuck at night) you would overload the system. This could cause either the stator or rectifier to fry.
Can a stator go bad from sitting?
Stators do not go bad from sitting unless the mag housing is full of water
.
How do you check for a bad stator?
Insert each probe into a stator socket. You should read around 0.2 to 0.5 ohms.
If you show an open circuit with the “Open” or infinity reading or have higher resistance
, then the stator is bad and you must replace it. If these tests all produce positive results, then the stator itself is good.
Can a bad stator drain a battery?
If the stator doesn’t provide enough power, the battery will begin to drain
. … Readings over 1.5 Ohms are an indication that the stator is faulty. Next, check to make sure nothing is going to ground by connecting the red lead to the connector and the black lead to the negative terminal of the battery.
Can you ride a Harley with a bad stator?
Battery: … The stator system charges your battery and replenishes it. You could actually run your motorcycle just fine for some time without a working stator as the battery has reserve current. Of course, the battery would eventually die.
What causes a Harley stator to burn out?
This voltage can be thousands of volts from just a 12 volt circuit. That
high voltage spike can punch through the enamel insulation
in the stator coils and cause them to short out.
What happens when the regulator rectifier goes bad?
In general, there are two primary ways that the regulator rectifier can fail. First,
the diode can burnout and cause the battery to drain
. … around 13 volts, the bike will start to drain the battery. When this happens, it’s only a matter of time before the engine stops completely.
Where is a stator located?
Stators are
inside the engine case
. An automotive style alternator is a fully self-contained, externally mounted unit that creates DC current. Another difference between stators and automotive style alternators is the type of magnet uses. Stators use a permanent magnet, and automotive alternators use an electro-magnet.
