Push the throttle cable toward the throttle valve body on the engine from the gas pedal position. Screw the throttle cable back in place on both the gas pedal and the throttle valve body on the engine. The golf cart will idle rather than shut off.
How do you reset the engine on a Club Car?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”.
Press and hold this button for a few moments and then release it to reset the motor
.
How do you service a Club Car golf cart?
How can I make my Gas Club Car DS faster?
How do you adjust the governor on a Club Car gas golf cart?
How do you adjust the carburetor on a Club Car DS?
Find the pilot adjustment screw on the edge of your carburetor. Pay attention to this screw – it should be a sharp point and not flat. Carefully remove this screw and then carefully screw it back. Turn this screw out one and one-half turns to adjust it properly.
First, you'll want to reset your motor.
Get out your handy screw driver and work to uncover the motor itself. It should have a small reset button (Usually it will be red) located
near the main battery supply
. Hit the reset button and then put the cover back on the motor.
Locate the motor
Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers.
Look in the area where several electrical wires enter the motor and locate a small red button
. This is the reset button.
How do you know if your golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition.
If your golf car won't start, is slower than it used to be, or is experiencing other technical problems
, you could have a bad motor on your hands.
How do you change the oil in a Club Car golf cart?
How much oil goes in a Club Car golf cart?
The gasoline engine on the Club Car golf carts hold
between 1 1/4 and 1 1/2 quarts
of 10W-30 engine oil. The oil filter for the Club Car golf cart can be found at major retail hardware stores or at a Club Car golf cart dealership/parts place.
How often should you change oil in a golf cart?
If your golf cart is used often, you'll want to check on it more than that. You'll need to replace your engine oil and filter
semi-annually, generally once it hits around 125 rounds or 600 miles of usage
. For new engines, your initial oil change should be after 8 hours of run time.
Where is the governor on a Club Car golf cart?
How do I increase the speed of my Club Car golf cart?
- Add More Torque to Your Golf Cart.
- Upgrade Your Golf Cart's Motor.
- Improve the High-Speed Controller of the Cart.
- Add Better Golf Cart Tires.
- Use a Higher Powered Golf Cart Battery.
- Watch the Weight in Your Golf Cart.
Will bigger tires make my golf cart faster?
Simply put, the better shape your tire is in and
the larger the diameter, the faster the cart will go
. This improves gas and electric golf cart speeds. Carts with thicker, larger tires possess more traction so, in turn, are generally safer as well.
How fast can a golf cart go without a governor?
Consult with your golf cart manufacturer, but replacing your speed control can increase your speed to 20 mph or more, depending on your upgrade. A typical electric cart without an upgraded speed control tops out around
12 mph
.
Why is my gas golf cart running slow?
Low Battery
Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
How do you adjust the governor on a electric club car?
Basically, an electric speed governor can be controlled by a tiny metal rod that's located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by
rotating the nut in a counterclockwise rotation
.
How do you clean the carburetor on a Club Car DS?
Spray the carburetor body inside and out with cleaner. Use the tube nozzle on the spray can to clean the jet ports, idle adjustment port and the choke plate. Use the bristle brush to clean dirt and deposits on the body. Wipe the carburetor with a dry cloth.
How do you adjust valves on a club car?
Why does my club car backfire?
Engine backfiring occurs when there is an air leak within your golf cart or sometimes when there is too much fuel inside
. This can cause the piston to slam against the cylinder head and cause a tapping sound. An essential component of any golf cart is the drive belt.
Do Club Car golf carts have fuses?
Club Car carts are like Yamaha and EZGO in that
they have their fuse boxes
in pretty specific locations that make them easier to access and repair. For example, those who may still be rocking a 1986 CC DS gas Club Car cart – and we envy you if you've got that baby still running – has the fuse box behind the dash.
How do you troubleshoot an electric club car?
- Test the wall socket where you charge your cart. …
- Expose your golf cart batteries. …
- Test the batteries for voltage. …
- Replace dead batteries. …
- Expose the motor for inspection. …
- Reset the motor. …
- Test the cart.
Where is the OBC on a club car?
Why did my golf cart just stop?
Solenoid Wear
When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
