Running a motorcycle without its baffles is not bad for the engine. It will not cause any engine damage . ... To get the most out of baffles removal, make sure to rejet or tune your motorcycle afterwards. This ensures you still have the right air / fuel ratio – allowing you to even gain some performance in the end.
Can you run a Harley without baffles?
Your bike will run without baffles – but if you just simply remove the baffles, without putting a good tune in your ECM to compensate, you will most likely notice a degradation in performance.
Do you need baffles in Harley exhaust?
Harley’s exhaust system has gotten quieter throughout its evolution. If you are looking for a way to add more sound, an easy way to do it is to remove the baffles. The baffles are located in the pipes of the exhaust system of your Harley and can be removed without damaging the bike.
Are motorcycle baffles necessary?
Most motorcycles come with a standard baffle or muffler required by law to reduce the engine’s natural noise levels . Removing the baffle will cause the exhaust to become freer flowing and release the exhaust gases quicker, making the bike louder.
Do you have to have baffles in Harley exhaust?
Save you money and do it the right way and purchase slip ons. It is recommended that any exhaust over 1.75′′ baffle needs to have a fueler installed to correct leanness from severely hurting engine ..
Do quiet baffles affect performance?
For a quick answer – quiet baffles will not impact performance (horsepower or torque) as much . You could lose a small amount of high end power but nothing significant. You might see it at a dyno but will not feel it.
Can you remove baffles on Screaming Eagle pipes?
Take the 14-gauge wire and shape it into a hook shape using the needle nose pliers. Then, slide the hook into one of the holes on the inside of the baffle. Clamp the vice grips to the baffle , and then hit the vice grips with the mallet. This is going to free up the baffle and allow it to be removed.
Does removing baffle increase power?
Removing the baffles will change how the engine runs . It will usually cause the engine to run leaner (less fuel), and a lean mixture burns much hotter that can cause damage. Removing the baffles will also mess up the power curve of the motor.
How do I make my motorcycle baffles quieter?
- Check for holes in your exhaust system. ...
- Replace the mufflers. ...
- Upgrade to better mufflers. ...
- Try wrapping the pipes. ...
- Invest in motorcycle exhaust silencer. ...
- Switch to new pipes.
How does baffle size affect sound?
If we’re talking about straight through pipes with no mufflers/baffles then a smaller diameter pipe will give you a snappier sound (high frequency) and a larger diameter pipe will give you a deeper sound (low frequency) . ... A baffle is a mechanical device used to disrupt sound waves.
Can I take the baffles out of my Harley exhaust?
The baffles are located in the pipes of the exhaust system of your Harley and can be removed without damaging the bike. You can take your bike to an authorized Harley Davidson shop to have this done, but the cost will be much higher than doing it yourself using tools that you likely have on hand.
Do you have to retune after removing baffles?
Removing your baffles will likely require a retune ...that really messes with the back pressure. If you listen to some other mufflers and inquire as to the manufacturer of some that you like, you’re more likely to better match the backpressure your present pipes have and not hurt your tune as much.
Can you cut baffles in half?
According to Rinehart, you can cut the baffles in half , and install just the back half.
Can you remove baffles from Rinehart slip ons?
Can I remove or change the baffles in my mufflers? ... For all other mufflers and systems, the baffles are not removable . Are replacement parts available for my Rinehart pipes? Yes, we do offer replacement heat shields, pipes, clamps, and more for all of our current systems.
Do Vance and Hines short shots have baffles?
| MODELS 2012-2017 SOFTAIL | FINISH CHROME | STYLE FULL SYSTEM, 2-INTO-2 | FEATURES OPTIONAL BAFFLE |
|---|
Are Vance and Hines Longshots loud?
The sound was loud and about 85-86 Db standing about 50 feet away . Then I took out the standard baffles that came with the Vance & Hines pipes. ... Then Installed these Baffles and the sound was much better, about 79-80 Db standing about 50 feet. I like the sound of the bike much better!
